TDL聚合物粘结砂浆

发布时间 2010-12-14 11:45:47

产品描述

产品编号:TDL-013(内)

Serial Number: TDL-013N

用 途:适用于外墙保温系统聚苯板的粘结。

Function: to stick EPS board as a constituent of external thermal insulation system

产品介绍:采用目前世界上**先进的三元共聚再分散粉料作为助剂生产的干粉砂浆,改变了传统水泥砂浆机理结构,形成了一个完整的三维网络,具有良好的抗裂性、粘结性、耐候性(耐老化)和防水透汽性。

Product Introduction: the most advanced redispersible powder is used as additive, which changes the composition of traditional mortar and forms a three dimensional net, so the product is anti-crack, adhesive, weatherproofing and waterproof.

技术性能:

项目

性能

拉伸粘接强度(与水泥板)

原强度,MPa

0.60

耐水强度,MPa

0.40

拉伸粘接强度(与聚苯板)

原强度,MPa

0.10

耐水强度,MPa

0.10

可操作时间, h

1.5-4.0

外观

单组分,干粉,灰色粉末

 

Technical Specifications:

Items

Specification

Tensile bond strength (with cement board)

PrimaryMPa

≥ 0.60

Water-tolerantMPa

≥ 0.40

Tensile bond strength (with EPS board)

PrimaryMPa

≥ 0.10

Water-tolerantMPa

≥ 0.10

Work life, h

1.5-4.0

Appearance

Single packinggray dry powder

 

包装、贮存与运输: 三复合牛皮纸包装,25kg/袋,防潮、防雨,存于阴凉干燥处,保质期6个月;按非危险品运输。

Package, Storage and Transportation: 25kg/sack, kept in dry, cool place, 6 months’ quality guarantee period, deliver by the way of non-dangerous goods

使用方法:

Usage:

1、基层处理:清理墙面表面疏松处、油污,剔凿或修补墙面平整度超差部分,要求墙面平整、清洁、干燥。

1. Base treatment: clean and level the surface of substrate

2、配制粘结砂浆:TDL013(内):水 =41 (重量比,使用电动搅拌器充分搅拌均匀,静置5-10分钟,再次搅拌即可使用,搅拌好的砂浆**好在2小时内用完,严禁将已凝固的砂浆二次搅拌再投入使用。

2. Mortar compounding: mix-ratio, TDL-013N: water = 4:1, fully mixed with electric mixer, standing for 5-10min, and mixed again; it is better to use up mixed mortar within 2 hours; no hardened mortar should be used.

3、粘贴聚苯板时,应采用点框法粘结,即用抹灰刀将搅拌好的粘结砂浆均匀涂抹在保温板边缘上形成边框,然后在板面上均匀分布6-8个高于边框的粘结点,**后按上述方法将聚苯板粘到墙面上并用靠尺靠平,粘结面积不得<40%

3. When sticking, evenly apply mixed mortar on the edge of EPS board, and then uniformly distribute 6-8 bonding points higher than the borders of EPS board in the plate surface, finally stick EPS board on substrate and level with running rule. The bonding area of EPS board should not be less than 40%.

4、参考消耗量:4-5kg/m2

4. Recommended quantity: 4-5kg/m2

注意事项:

Remark:

1、施工温度宜大于5℃ 以上,风力5级以下,避免雨天施工;在冬施情况下,应采用防冻型砂浆;

1. The favorable construction conditions: temperature >5, wind force<5, no construction no rainy days; frost-resistant mortar should be used in winter.

2、拌制好的砂浆应在2小时内用完 ,已凝固硬化的砂浆不得二次使用;

2. Mixed mortar should be used up within 2 hours; no hardened mortar should be used.

3、严禁工地现场私自添加砂子、水泥及其他添加剂。

3. No sand, cement or other additives should be mixed in construction site.

 

 

北京市建兴新建材开发中心
联系人 王冠华
联系电话 010-63983457 13810112545 
18611728991 
地址 北京宣武区广莲路甲5号建设大厦710室
邮箱 pillarpr@sina.com
进入店铺 在线留言

了解更多

商家产品导航