瓷砖胶（高效瓷砖粘接剂）

 瓷砖胶

一．  产品优势：

瓷砖胶又称陶瓷砖粘合剂，主要用于粘贴瓷砖、面砖、地砖等装饰材料，用途广泛，适用于内外墙面、地面、浴室、厨房等建筑的饰面装饰场所。其主要特点是粘接强度高、耐水、耐冻融、耐老化性能好及施工方便，是一种非常理想的粘结材料。该产品避免掉砖的风险，良好的柔韧性，有效防止生产空鼓，本产品是一种高效聚合物改性的水泥基瓷砖胶。

二．  施工工艺：

 

1. 施工前清理基层表面上的油污、灰尘、混凝土养护剂、脱模剂及其它松散物。

**步先将生活饮用水加入搅拌桶，再将粘结剂逐量加入，混合比例为粉剂：水=3.7~4：1，可以根据施工习惯适当改变粉料与水的比例，调节稀稠度。用低   速（300r/min）电动搅拌器搅拌均匀无生粉团。

2. 第二步水化（静置）15分钟后进行第二次搅拌1-3分钟即可使用，水化后的粘结剂不宜再加水或粘结剂干粉。

3. 用有齿抹刀直线的一边将少量粘结剂用力刮在瓷砖背面（填满凹槽为准），清除底面的灰尘和杂物，以保证粘结的强度。

4. 将适量的粘结剂涂在施工底面上，并用合适齿距的抹刀呈60-70度，沿直线的方向梳理成饱满的条状，将瓷砖按压在涂有粘结剂的基层上，以确保全面粘着并调整到恰当的位置。

5. 搅拌后的粘结剂应在4小时内用完，每半小时搅拌一次，使其保持较好的可操作性，已固化的粘结剂禁止使用。

6. 已贴好的瓷砖15分钟后不可再挪动，如需调整需清除瓷砖背面和施工面的粘结剂后重新用粘结剂粘贴。

 

 

 

注意事项：

1. 施用前必须先确认底材的垂直度及平整度。施工24小时定型后可进行表面后续施工（填缝），但不可使用有震落机械在施工面作业，7天后有一定强度，28天后达到**高强度。

2. 本产品含有水泥成分，如不慎溅入眼睛应及时用净水冲洗干净或及时去

医院诊治。

3. 施工时和施工后48小时不可水淋，温度在5℃-35℃。

4. 调好后的粘结剂应在2小时内用完，切忌把已干结的胶浆加水混合再用。

 

ceramic tile rubber

1.Advantages:

The ceramic tilerubber called the ceramic ceramic tile bond, mainly uses in gluing the ceramictile, the face brick, decoration materials and so on brick, the versatility, issuitable for construction and so on inside and outside wall surface, ground,bathroom, kitchen facings decorates the place.Its main characteristic is thecementation intensity high, water resistant, bears the freezing and thawing,bears the aged performance good and the construction is convenient, is one kindof extremely ideal cementing material.This product avoids the brick the risk,the good flexibility, prevented effectively produces the spatial drum, thisproduct is one kind of highly effective polymer modified cement base ceramictile rubber.

 

 

 

 

2.Construction craft:

1.Before the construction cleans up on the basic unit surface the greasy dirt,the dust, the concrete curing medicinal preparation, the release agent andother loose. First step will live the tap water to join first stirs the barrel,then will join the cementing agent by the quantity, the proportion of mixturewill be the medicinal powder: Water =3.7~4: 1, may act according to theconstruction custom suitable change powder material and the water proportion,adjusts the thin thickness.With low  Fast (300r/min) electrically operated mixer agitation even not freshfried glutinous rice cake.  

 

2.After the second step hydration (settlement) 15 minutes carries on second timestirs 1-3 minute then to use, after the hydrated cementing agent is notsuitable adds water or the cementing agent dried noodles again.

 

3. Withhas tooth trowel straight line one side to blow the few cementing agent effortat the back of the ceramic tile (fills up scoop channel for), eliminates thebottom surface the dust and the sundry goods, guarantees the caking theintensity.  

 

4.The right amount cementing agent will spread in the construction bottomsurface, and will assume 60-70 degree with the appropriate tooth pitch trowel,will comb the full strip shape along the straight line direction, will holdback the ceramic tile in spreads has in the cementing agent basic unit, willguarantee comprehensively holds to and adjusts the appropriate position.  

 

5.After the agitation cementing agent should use up in 4 hours, every half hourstirs one time, causes its maintenance good feasibility, solidified cementingagent prohibition use.  

 

6.After has pasted the good ceramic tile 15 minutes not to be possible again tomove, after if must adjust must eliminate at the back of the ceramic tile andthe construction surface cementing agent uses the cementing agent to glue.

 

 

 

3.matters needing attention：

1. Before theemployment must confirm the bottom material first the verticality andsmoothness.After constructs 24 hours stereotypia to be possible to carry on thesuperficial following construction (sealing), but cannot use has shakes fallsthe machinery on the construction surface work, after 7 days have certainintensity, after 28 days achieve the highest intensity.  

2. This productincludes the cement ingredient, if splashes into the eye to be supposedcarelessly promptly clean or goes to the hospital diagnosis promptly with onlythe water flushing.  

3. Whenconstruction and constructs the latter 48 hours not to be possible the water todrench, temperature in 5℃-35℃.  

4. Adjusts afterthe cementing agent to be supposed to use up in 2 hours, prohibited has againused the dry and hard glue watering mix.

了解更多